Kropp Forge Co. v. Secretary of Labor

Citation657 F.2d 119
Decision Date14 August 1981
Docket NumberNo. 80-2160,80-2160
Parties9 O.S.H. Cas.(BNA) 2133, 1981 O.S.H.D. (CCH) P 25,607 KROPP FORGE COMPANY, Petitioner, v. SECRETARY OF LABOR and Occupational Safety and Health Review Commission, Respondents.
CourtUnited States Courts of Appeals. United States Court of Appeals (7th Circuit)

Robert D. Moran, Washington, D. C., for petitioner.

John A. Bryson, Acting Sol. of Labor, U. S. Dept. of Labor, Washington, D. C., for respondents.

Before CUMMINGS, Chief Judge, SWYGERT, Senior Circuit Judge, and JAMESON, Senior District Judge. *

CUMMINGS, Chief Judge.

Kropp Forge Company has filed a petition to review an order of the Occupational Safety and Health Review Commission holding that Kropp violated 29 U.S.C. § 654(a)(2) 1 because of noncompliance with an occupational safety and health standard, codified at 29 C.F.R. § 1910.95(b)(3), that provides in full:

"In all cases where the sound levels exceed the values shown herein, 2 a continuing effective hearing conservation program shall be administered."

The citation against Kropp charged, and after a hearing the Administrative Law Judge (ALJ) found that noise levels generated by forging hammers at Kropp's Chicago steel forging plant continuously exceeded 90 decibels and that Kropp's hearing conservation program lacked six elements necessary to constitute an effective program as required by the above-quoted standard. 3 The ALJ further found that the violation was "willful-serious" as charged and assessed a penalty of $5000. The Commission declined Kropp's petition for discretionary review so that the ALJ's July 2, 1980, opinion became the final order of the Commission on August 7, 1980, pursuant to 29 U.S.C. § 661(i). We conclude that the standard under which Kropp was cited is unenforceably vague and therefore reverse.

As a preliminary matter, we reject Kropp's contention that all evidence gathered during two December 1978 Occupational Safety and Health Administration (OSHA) inspections should have been suppressed on the ground that it was obtained pursuant to a warrantless search in violation of the Fourth Amendment. Kropp concedes that it granted OSHA permission to enter its premises on these occasions to verify an employee complaint, unrelated to the present charges, concerning excessive exposure to carbon monoxide fumes from fork-lift trucks. At the time of her first visit to the plant, on December 5, 1978, the OSHA compliance officer stated that her inspection would not go beyond the area of the complaint, i. e., the plant's "KFA Building" where the fork-lift trucks were located. However, after making an initial walk around the building, the compliance officer determined that sampling of noise levels generated by forging hammers located in the KFA Building was also required. Accordingly, the inspection was continued on December 13 and 19, at which times sampling for both carbon monoxide and noise levels was conducted. 4 Kropp argues that its consent was limited specifically to the carbon monoxide investigation so that the noise level samples were taken unlawfully.

The record shows, however, that at all times on December 13, the compliance officer was accompanied by Kropp's Safety Director and that on December 19, she and a second compliance officer were accompanied by the Safety Director and Kropp's General Manager. Both men had been informed that noise sampling would be conducted, and they raised no objections to the approximately five hours of sampling conducted on each day. Moreover, the Safety Director requested and received the results from the noise sampling taken on both days. While it is true that Kropp refused entry to a compliance officer seeking to continue the noise inspection in January 1979, the only surveys attacked by Kropp are those that took place on December 13 and 19. 5 Since Kropp's representatives were present at all times during those inspections and did not raise any objections when informed of the intended sampling, any Fourth Amendment objection to those surveys was waived. Marshall v. Western Waterproofing Co., Inc., 560 F.2d 947, 950-951 (8th Cir. 1977); Dorey Electric Co. v. OSHRC, 553 F.2d 357, 358 (4th Cir. 1977).

Kropp next argues that the standard which it is said to have violated does not provide "fair warning" of what is required or prohibited and is therefore unenforceably vague under United States v. L. Cohen Grocery Co., 255 U.S. 81, 41 S.Ct. 298, 65 L.Ed. 516, and its progeny. 6 We agree. The rationale of Cohen Grocery has been applied in a number of decisions under the Occupational Safety and Health Act. In Dravo Corporation v. OSAHRC, 613 F.2d 1227, 1234 (3d Cir. 1980), for example, an employer was held not to be subject to sanctions for non-compliance with safety standards "without adequate notice in the regulations of the exact contours of his responsibility." The court applied the traditional rule that the applicability of penal sanctions in regulations is to be narrowly construed by the judiciary and stated that OSHA regulations must "be written in clear and concise language so that employers will be better able to understand and apply them," quoting from Diamond Roofing Co. v. OSAHRC, 528 F.2d 645, 650 (5th Cir. 1976). See also Bethlehem Steel Corporation v. OSAHRC, 573 F.2d 157, 161-162 (3d Cir. 1978); 4 Davis, Administrative Law Treatise § 301.2. The regulation in issue here, providing only that "a continuing effective hearing conservation program shall be administered," misses the mark considerably.

Kropp, as noted, was cited for non-compliance because its program lacked the following six elements:

1. Annual audiometric tests.

2. Referral of employees to a physician.

3. Re-tests of employees with significant threshold shifts.

4. Selection and use of hearing protection.

5. Training in use of hearing protectors.

6. Enforcement of proper wearing of hearing protectors.

However, the standard does not give any warning to employers that their conservation programs must contain these six elements. Indeed, in proposing a change in the standard in 1974, the Secretary of Labor stated:

"The current standard * * * does not explicitly require monitoring of the sound level of the employee's surroundings nor measurement of the individual employee's resulting exposure" (39 Fed.Reg. 37,774 (1974)).

Also a 1972 document that the Labor Department published as "A Guide to OSHA Standards," notes that "(s)ince audiometric tests are not specifically mentioned in the regulations, they are not specifically required" (App. 136). That publication defined "hearing conservation program" in the regulatory standard as referring to "audiometry periodic checks on the hearing ability of individual employees and to noise surveys periodic checks of the noise level in the area in which employees are working" (Idem.). This official definition, which was satisfied by Kropp, does not contain the six elements Kropp was cited as failing to provide. Similarly, an OSHA Field Information Memorandum in 1974 provided that OSHA's official policy was "not requir(ing) audiometric testing" (App. 161; emphasis in original), again contradicting the present citation.

Even the compliance officer who conducted the December 1978 inspections of Kropp's plant testified that the six elements listed in the citation were not required by the then controlling regulation (App. 165-166) nor thought by her to be included in the standard (Tr. 490), and had not been included in a Field Operations Manual until April 20, 1979 (App. 40, 64), whereas the alleged violations here occurred in December 1978. Furthermore, on January 16, 1981, too late for this case, OSHA removed the one-sentence standard at issue in this case and replaced it with a new regulation which, like the 1974 proposal, contains all six elements listed on the citation at issue in this case (46 Fed.Reg. 4162-4164), thus acknowledging that these elements were not previously included in the standard before us.

Finally, it is noteworthy that in Secretary of Labor v. B. W. Harrison Lumber Company, 4 BNA OSHC 1091 (1976), an Administrative Law Judge held that 29 C.F.R. § 1910.95(b)(3), the regulation involved here, was unenforceably vague. His vacation of the OSHA noise citation was affirmed by the Commission by a 2-1 vote. One of the two majority members affirmed the ALJ on the vagueness ground, whereas the other majority member affirmed the disposition because the citation did not conform to the statutory criteria. Although the Fifth Circuit affirmed the Commission because of the invalidity of the citation, the 1978 opinion of the court held that the citation reference to 29 C.F.R. § 1910.95(b) (3) was deficient because it merely parroted the words in the regulation that the employer failed to provide "a continuing effective hearing conservation program" and did not inform the employer of what was charged. 569 F.2d 1303, 1309. After this 1978 opinion of Judge Godbold, the Secretary had ample opportunity to amend the regulation, so that it would give proper notice to an employer and finally did so in January 1981. 7 More recently, in Secretary of Labor v. Kraft Food, Inc., 9 BNA OSHC 2040 (March 17, 1981), an ALJ again found 29 C.F.R. § 1910.95(b)(3) unenforceably vague. This decision, in direct conflict with the result in this case, became a final order of the Commission on May 18, 1981.

The ALJ rejected Kropp's vagueness argument because

"The standard does not involve criminal or First Amendment activity and if the regulation affords reasonable warning of the proscribed conduct in light of common understanding, it is not constitutionally vague" (App. 5). 8

His decision is erroneous because the pertinent parts of the OSH Act and regulations do impose "penal sanctions," 9 and the regulation in issue does not give reasonable notice of the conduct said to be prohibited "in light of the common understanding." Indeed the ALJ himself acknowledged that the six elements of the...

To continue reading

Request your trial
17 cases
  • Shell Oil Co. v. Babbitt
    • United States
    • U.S. District Court — District of Delaware
    • November 14, 1996
    ...on the other hand, clearly relates to royalty valuation; it was not hidden so that Shell would be misled. In Kropp Forge Co. v. Secretary of Labor, 657 F.2d 119 (7th Cir.1981), a steel forging plant was fined $5000 because noise levels generated by its hammers exceeded 90 decibels and the p......
  • Faultless Div., Bliss & Laughlin Industries, Inc. v. Secretary of Labor
    • United States
    • United States Courts of Appeals. United States Court of Appeals (7th Circuit)
    • March 30, 1982
    ...employer conduct is proposed to be derived from a very general statutory or regulatory command. See, e.g., Kropp Forge Co. v. Secretary of Labor, 657 F.2d 119 (7th Cir. 1981) (noise regulation-29 C.F.R. § 1910.95(b) (1980)); S & H Riggers & Erectors, Inc. v. OSHRC, 659 F.2d 1273 (5th Cir. 1......
  • U.S. v. Southern Indiana Gas and Elec. Co.
    • United States
    • U.S. District Court — Southern District of Indiana
    • February 13, 2003
    ...Safety and Health Review Comm'n, 827 F.2d 46 (7th Cir.1987); Metro-East Mfg. Co., 655 F.2d 805 (7th Cir. 1981); Kropp Forge Co. v. Sec'y of Labor, 657 F.2d 119 (7th Cir.1981); Diamond Roofing Co. v. OSHRC, 528 F.2d 645 (5th Cir.1976). The fair notice doctrine (also called fair warning) in t......
  • Simplex Time Recorder Co. v. Secretary of Labor
    • United States
    • United States Courts of Appeals. United States Court of Appeals (District of Columbia)
    • July 5, 1985
    ...during the actual inspection, works against Simplex. The Seventh Circuit considered like circumstances in Kropp Forge Co. v. Secretary of Labor, 657 F.2d 119 (7th Cir.1981). The written complaint which led to the inspection in Kropp alleged a carbon monoxide hazard. During the initial inspe......
  • Request a trial to view additional results
1 firm's commentaries
1 books & journal articles
  • Law, Fact, and the Threat of Reversal From Above
    • United States
    • American Politics Research No. 42-2, March 2014
    • March 1, 2014
    ...No613 F.2d 1025 Yes Yes616 F.2d 65 Yes No619 F.2d 563 Yes No628 F.2d 36 No Yes628 F.2d 1283 Yes No631 F.2d 944 Yes Yes635 F.2d 891 Yes No657 F.2d 119 No Yes666 F.2d 454 No Yes675 F.2d 106 No Yes677 F.2d 22 Yes Yes683 F.2d 858 Yes No691 F.2d 953 Yes Yes692 F.2d 169 Yes NoAppendix B. Smith 24......

VLEX uses login cookies to provide you with a better browsing experience. If you click on 'Accept' or continue browsing this site we consider that you accept our cookie policy. ACCEPT