Jones v. Stemco Mfg. Co., Inc.

• Decision Date: 03 February 1981
• Docket Number: No. 52554,52554
• Citation: 624 P.2d 1044,1981 OK 10
• Parties: Linda JONES, Administratrix of the Estate of John Vernon Jones, deceased, Appellant, v. STEMCO MANUFACTURING COMPANY, INC., a Texas Corporation dba Garlock, Inc., a Delaware Corporation, and Oklahoma Truck Supply Assoc., Inc., an Oklahoma Corporation, Appellees.
• Court: Oklahoma Supreme Court

Page 1044

624 P.2d 1044

1981 OK 10

Linda JONES, Administratrix of the Estate of John Vernon Jones, deceased, Appellant, v. STEMCO MANUFACTURING COMPANY, INC., a Texas Corporation dba Garlock, Inc., a Delaware Corporation, and Oklahoma Truck Supply Assoc., Inc., an Oklahoma Corporation, Appellees.

No. 52554.

Supreme Court of Oklahoma.

Feb. 3, 1981.

Rehearing Denied March 16, 1981.

An appeal from the District Court of Oklahoma County; Carmon C. harris, judge.

Plaintiff appeals from an adverse jury verdict in a manufacturers' products liability action. Appellant complains of the introduction of evidence based on an out of court experiment, and use of the word "fault" in the instructions to the jury.

REVERSED AND REMANDED.

Robert D. Baron, Berry, Baron & Berry, Oklahoma City, for appellant.

Harry R. Palmer, Jr., Oklahoma City, for appellee, Stemco dba Garlock.

K. David Roberts, Oklahoma City, for appellee, Oklahoma Truck Supply Assoc., Inc.

SIMMS, Justice:

This is an appeal from a jury verdict for the defendants in a manufacturers' product liability action. Plaintiff (appellant) claims the trial court erred by admitting the results of an inadmissible and prejudicial out-of-court experiment, and by using the word "fault" in the instructions to the jury.

Plaintiff brought her action for the wrongful death of her husband. On the evening of February 1, 1975, plaintiff's husband was driving a loaded tractor-trailer truck owned by American Farm Lines west on Interstate 40. He was following a similar truck (No. 2032) owned by the same company. Approximately 50 miles from the American Farm Lines yard, the first truck caught fire and lost a drive wheel which rolled to the center of the highway. The truck driven by plaintiff's husband came around a curve, hit the wheel, went out of control and off a bridge, resulting in the death of the driver and his passenger.

Earlier that day, an American Farm Lines mechanic noticed oil leaking from the drive wheels of truck no. 2032. He removed the wheels and replaced an oil "hub seal" with one manufactured by the defendant, Stemco Manufacturing Co., Inc., and sold by the defendant, Oklahoma Truck Supply Assoc., Inc. Plaintiff claims that this "hub seal" was defective, causing truck no. 2032 to catch fire and lose its wheel, resulting in the accident in which her husband died.

Plaintiff's only expert witness was a metallurgist from Houston, Texas. He testified that in his opinion, based on post-accident investigation of the Stemco "hub seal" and the axle assembly of truck no. 2032, the leather skirt around the Stemco seal, which is designed to hold the oil in the axle, came loose, allowing oil to escape. He testified that this caused an insufficient supply of oil to reach the outer wheel bearing, which then caught fire, destructed, and caused the wheel to come off the axle. He further testified that this loosening of the leather skirt would constitute a defect in the Stemco oil seal.

The defendants introduced the testimony of two Stemco employees that, in their experience, if the leather skirt had come loose, there would have been a massive loss of 90 weight differential oil, which would have covered the entire wheel, axle, and brake assemblies. Testimony and photographs introduced showed very little oil covering these assemblies after the accident.

The defendants then introduced the testimony, over plaintiff's objection, of Dr. Donald Boyd, Professor of Mechanical and Aerospace Engineering at Oklahoma State University. His testimony was based on the results of the experiment complained of on appeal.

Dr. Boyd testified that he removed the drive wheels of a truck that had a similar axle design to that of truck no. 2032, and a hub seal similar to Stemco's, but with a rubber (instead of a leather) skirt holding in the oil. He cut this rubber skirt purposefully to induce an oil leak, and then drove the truck a number of miles. He then testified that this experiment showed that if the oil hub seal had leaked, there would have been a significant amount of oil thrown out of the axle and onto the wheel, axle, and brake assemblies.

Dr. Boyd concluded, based on this experiment, and on the photographs of the accident vehicle no. 2032, that the truck lost its wheel when a faulty outer wheel bearing overheated, not because of a defective oil seal.

Plaintiff objected to the admission of this testimony because of alleged dissimilarities between the tested vehicle and the accident vehicle no. 2032. On questioning by the Court, Dr. Boyd admitted some dissimilarities, but claimed that the conditions were sufficiently similar for him to render an opinion of which he could be confident.

Defendants correctly cite the rule in Oklahoma that experiments may be admissible even if not done under identical conditions as those of the incident involved, and, if done under reasonably similar conditions, the condition under which the experiment was made goes to the weight of the evidence but not to its admissibility. C. F. Church, etc. v. Golden, Okl., 429 P.2d 771 (1967). Further, that the qualifications of an expert witness and the admissibility of experiment evidence are matters generally within the discretion of the trial court, which will not be reversed unless an abuse is clearly made to appear. Chickasha Cotton Oil Co. v. Hancock, Okl., 306 P.2d 330 (1957). Sinclair Oil & Gas Co. v. Albright, 161 Okl. 272, 18 P.2d 540 (1933).

Defendants contend that the trial court carefully and correctly exercised its discretion, admitting the testimony after extensive questioning of the witness. Plaintiff claims that the conditions of the experiment were so dissimilar to those of the accident that the trial court abused its discretion by admitting the testimony based thereon.

The circumstances under which an experiment is conducted do not merely go to the weight of such evidence. The experiment must possess sufficient probative value to warrant its admissibility initially. Enghlin v. Pittsburg County Ry. Co., 169 Okl. 106, 36 P.2d 32 (1934). Generally, evidence as to the results of an experiment is admissible only where it is shown that the conditions under which the experiment was made were the same or similar to the circumstances prevailing at the time of occurrence involved in the controversy. Drake v. Tims, Okl., 287 P.2d 215 (1955).

In Ruth Fuel Co. v. Nichter et al., 174 Okl. 601, 51 P.2d 502 (1935), we said:

"... the criterion for the admissibility of such evidence is whether such evidence tends to enlighten the jury and enable them to more intelligently determine the issue presented. Where the experiment offered is inconclusive or raises, or may raise, a number of collateral issues, or is not a sufficiently precise duplication of material facts being on a particular issue, then such evidence should not be admitted."

Plaintiff cites numerous dissimilarities of conditions in support of her proposition that the experiment and the testimony resulting therefrom were inadmissible: (1) the experiment vehicle was a wrecker, and 12 years older than truck no. 2032, which was used for hauling freight; (2) the hub seal destroyed in the experiment vehicle was not a Stemco seal, and was in fact of unknown manufacture and composition; (3) the experiment vehicle had a different brake assembly than that of truck no. 2032; (4) the witness did not know the mileage of the experiment vehicle; (5) there was no testimony of the similarity of the type and condition of the wheel bearings of the two vehicles; (6) the experiment vehicle was driven in a "stop and go" manner on a winding road while truck no. 2032 was driven at a steady speed on an interstate highway; (7) there was no similarity between the actual speed of the two vehicles; (8) the experiment vehicle had no load on the fifth wheel, as had truck no. 2032; (9) the experiment vehicle was not set on fire to see what effect this would have on the existence of oil around the wheel assembly; and, (10) there was no evidence that the size of the defect (leak) created by the witness was in any way similar to the defect claimed by plaintiff's witness to be the cause of the accident.

On review of the record, we conclude that the experiment admitted was not a sufficiently similar duplication of the conditions at issue to warrant its presentation to the jury, and the trial court abused its discretion by admitting testimony based thereon. Further, plaintiff was clearly prejudiced by its admission, especially considering that the plaintiff first learned of the experiment when it was offered into evidence at the trial.

Since this matter may come for re-trial, we find it necessary to address plaintiff's next proposition. Plaintiff contends that the use of the word "fault" in the jury instructions was improper in a manufacturers'...